Page tree

Versions Compared

Key

  • This line was added.
  • This line was removed.
  • Formatting was changed.
Section
Column
width65%

Oil filter housing bracket (pedestal), removing and installing (M52, M52 TU, M54 engines)

  • Disconnect battery negative (minus) cable and cover cable end with insulating material.
  • Loosen oil filter cover to allow oil in filter housing to drain into oil pan.
  • Remove alternator drive belt and unbolt alternator from oil filter housing bracket.
  • Empty power steering reservoir tank and then unbolt tank and move to one side (lines remain connected).
  • Unbolt power steering pump from oil filter housing bracket pump (lines remain connected).
  • Remove alternator drive belt tensioner.
  • Disconnect electrical connector from oil pressure switch.
  • Disconnect electrical connector for oil temperature switch.
  • Disconnect VANOS solenoid oil pressure line from oil filter housing.
  • Remove bolts (arrows) and remove complete oil filter housing bracket.

  • Remove oil filter housing profile gasket and install new gasket (arrow).

Installation is reverse of removal. Keep in mind the following:

  • BMW does not specify a unique torque for the oil filter housing bracket bolts. General tightening torque based on bolt grade is given below.
Info
titleNOTE

Bolt grade is marked on bolt head

  • Be sure to align bracket to locating dowels (arrows).

  • Reconnect all harness connectors previously removed.
  • Check engine oil level and power steering fluid level upon job completion.
  • Reconnect battery negative (minus) cable.
Panel
bgColor#fff
titleBGColor#eee
titleTightening torque
borderColor#999

M8 (8.8 grade). . . 24  NM (18 ft-lb)
M8 (10.9 grade). . . 34 NM (25 ft-lb)

Column
width35%
Warning
titleBefore Performing any Work

Please read Warnings & Cautions before proceeding with any work on your vehicle

Panel
bgColor#fff
titleBGColor#ddd
titleRelated Technical Manuals
borderColor#999

More BMW products...

Panel
bgColor#fff
titleBGColor#ddd
titleTechnical Discussion Forums
borderColor#999
RSS Feed
max5
showTitlesOnlytrue
urlhttp://tech.bentleypublishers.com/rss/rssthreads.jspa?forumID=72
titleBarfalse

more...

Subscribe to RSS feed

Log in